Air King Blower B500 User Manual download pdf

www.airkinglimited.com

111597002 New 3-07

1 of 8

READ AND SAVE THESE INSTRUCTIONS

READ CAREFULLY BEFORE ATTEMPTING TO ASSEMBLE, INSTALL, OPERATE OR MAINTAIN THE PRODUCT DESCRIBED. PROTECT

YOURSELF AND OTHERS BY OBSERVING ALL SAFETY INFORMATION. FAILURE TO COMPLY WITH

INSTRUCTIONS COULD RESULT IN PERSONAL INJURY AND/OR PROPERTY DAMAGE!

RETAIN INSTRUCTIONS FOR FUTURE REFERENCE.

GENERAL SAFETY INFORMATION

When using electrical appliances, basic precautions

should always be followed to reduce the risk of fire,

electric shock and injury to person, including the following:

WARNING: TO REDUCE THE RISK OF FIRE, ELECTRIC SHOCK AND

INJURY TO PERSON, OBSERVE THE FOLLOWING:

1. Read all instructions before installing or using range hood.

2. Use this unit only in the manner intended by the manufacturer. If you have

questions, contact the manufacturer.

3. Before servicing or cleaning the unit, switch power off at service panel

and lock the service disconnecting means to prevent power from being

switched on accidentally. When the service disconnecting means cannot

be locked, securely fasten a prominent warning device, such as a tag, to

the service panel.

4. Installation work and electrical wiring must be done by qualified person(s)

in accordance with all applicable codes and standards, including fire-

related construction.

Models B300, B500 Blower

SAVE THESE INSTRUCTIONS

5. Sufficient air is needed for proper combustion and exhausting of gases

through the flue (chimney) of fuel burning equipment to prevent back

drafting. Follow the heating equipment manufacturer’s guideline and safety

standards such as those published by the National Fire Protection

Association (NFPA) and the American Society for Heating, Refrigeration,

and Air Conditioning Engineers (ASHRAE), and the local code authorities.

CAUTION: FOR GENERAL VENTILATING USE ONLY. DO NOT USE TO

EXHAUST HAZARDOUS OR EXPLOSIVE MATERIALS AND VAPORS.

6. To avoid motor bearing damage and noisy and/or unbalanced impellers,

keep drywall spray, construction dust, etc. off power unit.

7. Refer to the instructions included with the Range Hood Canopy for additional

safety information.

IMPORTANT INSTRUCTIONS -

OPERATING MANUAL

INSTALLATION INSTRUCTIONS

CAUTION:

MAKE SURE POWER IS SWITCHED OFF AT SERVICE PANEL

BEFORE STARTING INSTALLATION.

WARNING: THIS BLOWER IS INTENDED FOR USE ONLY IN AIR KING

PROFESSIONAL SERIES RANGEHOOD CANOPIES MARKED SUITABLE FOR USE

WITH THIS BLOWER. DO NOT TO INSTALL IN ANY OTHER APPLICATION.

SECTION 1

Preparing for installation

NOTE: Before installing blower, make sure range hood canopy is properly

installed and securely in place. See “Range Hood Mounting Instructions”.

1. Unpack blower from the carton and confirm that all pieces are present. In

addition to the blower you should have:

8 - 8-32 Screws

8 - Washers

1 - Fuse

1 - Wire Harness

1 - Instruction/Safety Sheet

2. The installation of the blower is slightly different from one canopy height

to another. For 18" high canopies proceed to Section 2, for 10" high canopies

proceed to Section 3.

Figure 1

Keyholes

Stud w/Hex Nuts

Screw Stud

SECTION 2

Installation into 18" High Canopy

1. Lift blower up into the hood canopy and slide the keyhole slots in the blower

mounting flange over the two studs of the hood. Slide the blower into place

and tighten the hex nuts on the mounting stud while lining up the 8 holes

in the blower mounting flange to the 8 screw studs of the hood (Figure 1).

1 2 3 4 5 6 7 8

Summary of Contents

Page 1 - OPERATING MANUAL

www.airkinglimited.com111597002 New 3-071 of 8READ AND SAVE THESE INSTRUCTIONSREAD CAREFULLY BEFORE ATTEMPTING TO ASSEMBLE, INSTALL, OPERATE OR MAINTA

Page 2 - REPLACEMENT PARTS DIAGRAM

www.airkinglimited.com111597002 New 3-072 of 84. Plug the 3 wire quick connect cord from the blower into the receptacle onthe range hood canopy. Plug

Page 3 - 111597002 New 3-07

www.airkinglimited.com111597002 New 3-073 of 8

Page 4

www.airkinglimited.com111597002 New 3-074 of 8LIRE ET CONSERVER CES INSTRUCTIONSLIRE SOIGNEUSEMENT AVANT DE TENTER D’ASSEMBLER, INSTALLER, OPÉRER OU D

Page 5 - SECTION 3

www.airkinglimited.com111597002 New 3-075 of 84. Brancher le cordon à raccord rapide à 3 fils de la soufflante dans leréceptacle sur le couvercle de l

Page 6

www.airkinglimited.com111597002 New 3-076 of 8

Page 7

www.airkinglimited.com111597002 New 3-077 of 8LEA Y GUARDE ESTAS INSTRUCCIONESLEA CUIDADOSAMENTE ANTES DE INTENTAR MONTAR, INSTALAR, OPERAR O MANTENER

Page 8 - DIAGRAMA DE REPUESTOS

www.airkinglimited.com111597002 New 3-078 of 84. Conecte el cable de conexión rápida de 3 alambres desde el soplador altomacorriente ubicado en la bóv

Comments to this Manuals

No comments

Air King Blower B500 User Manual

Browse online or download User Manual for Unknown Air King Blower B500. Air King Blower B500 User's Manual

Summary of Contents

Comments to this Manuals

Related products and manuals for Unknown Air King Blower B500